Products

APPLICATION INFORMATION

•  Generator sets are assembled to meet the specifications of the user.
• The standard generator set is supplied ready to run except for coolant and lubricating oil.

THE GENERATOR SET IS SUPPLIED COMPLETE WITH THE FOLLOWING FEATURES:

• Four point mounting system
• Four-cycle water cooled diesel engine
• Radiator cooled, direct mounted
• Pusher fan
• Heavy-duty dry cartridge-type air filter
• High-coolant temp and low oil pressure shutdown sensors
• Spin-on fuel and oil filter
• Hour-meter – Set mounted
• Single side service
• Critical Grade Silencer
• Set-mounted start control panel
• Direct coupling between alternator and engine
• Fuel block for fuel connections
• Base drip pan
• Battery charging
• 120/240 or 120 volt full power connection
• U.L. listed circuit breakers-set mounted
• Start-stop switch – set mounted

*Warranty – 2 years/3000 hours SPECIFICATIONS ARE SUBJECT TO CHANGE WTHOUT NOTICE

ELECTRICAL SYSTEM

• 12 volt system with battery charging alternator and starter motor.

BASEFRAME

• Generator set is mounted on a heavy-duty fabricated and welded steel base pan.

COOLING RADIATOR SYSTEM

• Permits operation at ambient temperature to 120° F.

COUPLING AND MOUNTING

• The engine flywheel is flexibly coupled to the alternator rotor by means of a SAE flange. This prevents misalignment after prolonged use.

ANTI-VIBRATION MOUNTING PADS

• Affixed between the engine/alternator feet and the baseframe to isolate vibration of the rotating assemblies.

ENGINE FILTRATION SYSTEM

• Heavy-duty dry-type air filters, with replaceable elements suitable for use in dusty conditions, are supplied with each unit. Fuel filter and lubricating oil filters also have replaceable elements.

EXHAUST SYSTEM

• Heavy-duty industrial capacity exhaust silencer.

SAFETY GUARDS

• The fan, fan drive, and battery charging alternator drive are fully guarded for personnel protection.

FACTORY TESTED

• Each generator set is load tested at the factory before shipment. During the testing the generator set and its systems are tested as a complete unit. Control functions, site load conditions and potential system faults are simulated.

OPTIONAL EQUIPMENT

• Remote start/stop gauge panel
• Auto-start
• Voltage option
• Engine water jacket heater
• Electronic governors
• Low-noise exhaust silencers
• Air bag mounting
• Slide rack for mobile installation
• Special requirements testing
• Belt guard with surge tank for remote radiator
• Suction fan
• 3-phase multi-voltage options
• Dual phase
• 50 Hz, 1500 RPM, single or three phase

• CARB & EPA Certified Engine 1800 RPM Water Cooled
• Quiet, Powerful, Water cooled, Diesel Engine
• Designed for Mobile – Low Noise and Low Vibration
• High Ambient Radiator · Dependable ECU Controller